Nautique 100077 Manuel d'utilisateur Page 1

iDear Nautique Owner,Welcome to the Nautique Family! For over 80 years, Nautique hasbeen dedicated to providing our customers and their families witht

xNAUTIQUE COASTAL EDITION LIMITEDWARRANTY...W-5Lifetime LimitedWarranty...W-5Transferable LifetimeLim

4-28Section 4Tachometer/Fuel MonitorThe Tachometer/Fuel Monitor provides both the functions of atachometer and a fuel – engine monitoring system. The

4-29Controls and IndicatorsEngine Hour MeterDisplays the number of hours the engine has been operated. Thedisplay will show “XXXX.XHr.” Engine hours o

4-30Section 4VoltmeterDisplays the System Voltage. There are no adjustments available. Oil Pressure Displays the current Oil Pressure. There are no ad

4-31Controls and IndicatorsTachometer Display SequenceLCD Alarm Condition DisplaysAlarm messages will be displayed on the Tachometer LCD display.All m

4-32Section 4Severe Conditions – Includes a Flashing Red LightWarnings Engine Speed Limiter ActiveKnock Detection System MalfunctionSpark Delivery Sys

4-33Controls and IndicatorsSwitchesEach electrical circuit on your boat is equipped with a controlswitch. The switches have an indicator light for eas

4-34Section 4NOTICEIf either or both of the two light functions are on, the indicatorlight will illuminate and a press and release will turn off any o

4-35Controls and IndicatorsOptional Dash Pod Circuit Breaker BoxAll dash pod switches interface with a sealed circuit breaker boxlocated in the driver

4-36Nautique LINC SystemProduct InformationThe Nautique LINC System display is designed for instrumentationand control on electronically controlled en

4-37Basic Navigation FeaturesAll product features are easily accessed through Quick Access Keys,Menus, and Popup Controls. Quick Access KeysThese key

1-1Section 1Boating SafetySafety While BoatingBoating-related accidents are generally caused by the operator’sfailure to follow basic safety rules or

4-38Quick Access Key FeaturesThis section describes the features accessed through the QuickAccess Keys located to the left of the display. These feat

4-39Gauge Display - Soft Key CommandsControls and IndicatorsVIDEO ON / OFF – displays full-screen input from video in.Pressing the key a second time o

4-40Section 4CRUISE SETUP – accesses user profiles and cruise controlsThe Cruise feature is explained in more detail in the “Cruise SetupScreen” secti

4-41GPS DisplayThe GPS Display screen can be accessed by pressing the Quick Access Keyor by selecting “GPS Display” from the Menu options. The GPS fe

4-42GPS Display - Soft Key CommandsSection 4UP – LEFT – RIGHT - DOWN – facilitates navigation of the GPSmap by moving the cross-hairs accordingly.SPLI

4-43Controls and IndicatorsTRACK INFO – Tracking shows the current route and anywaypoints you have set. A green arrow indicates your currentposition,

4-44Clarion AudioClarion Audio can be accessed by pressing the Quick Access Key orby selecting “Clarion Audio” from the Menu options. This feature p

4-45Controls and IndicatorsPLAY/PAUSE – toggles between Play and Pause modes when aCD is playing.MUTE – mutes the sound for both FM Band and CD Disc.S

4-46Cruise Gauge ScreenThe Cruise Gauge Screen can be accessed by pressing the Quick AccessKey or by selecting “Cruise Gauge Screen” from the Menu opt

4-47Cruise Gauge Screen - Soft Key CommandsControls and IndicatorsCHANGE USER – select a predefined user.Additional Soft Key Commands for Change User

1-2• DO NOT operate the boat while under the influence of alcohol or other drugs.• DO NOT stand or allow passengers to stand in the boat, orsit on t

4-48Section 4VIDEO ON/OFF – toggles the video on or off. Pressing VideoOn/Off from the Cruise Gauge screen launches a small videowindow overlay, allow

4-49Controls and IndicatorsAdditional Soft Key Commands for Cruise Setup include:NEW USER – provides an interface to add new user information.Use PREV

4-50Section 4Additional Soft Key Commands for Load USB include:COPY ALL – copies every entry in the currently selected list to theopposite list.DELETE

4-51MENU OptionsThe MENU is displayed by pressing . The following features areavailable:• Gauge Display – provides a series of screens that displayen

4-52• Cruise Settings – facilitates creation and maintenance ofrider/skier profiles for cruise controls based on userpreference for speed. This featu

4-53Engine DiagnosticsWhen choosing this selection, the display will query the engine(s)ECU and provide feedback on any diagnostic codes that have bee

4-54• FMI – “Failure Mode Indicator” - fault codeThe FMI is defined by SAE J1939. If not translated into text,see the SAE standard, or the engine man

4-55How to Hide/Show FaultsTo hide the fault code pop-up being displayed on the screen, pressthe soft key next to the “Hide” icon. The pop-up will dis

4-56User SettingsUser Settings provide options to specify viewing preferences.Pressing PREV and NEXT navigates through the options, and UPand DOWN scr

4-57NavLightEnabling NavLight allows the unit to automatically display in NightView when the NavLight switch on the console is flipped to ‘On’.You can

1-3• Seek shelter from open water if there is threat of lightning.• Operate slowly in congested areas such as marinas andmooring areas.• The bow ma

4-58Audio IntensityThis function allows the user to program the Nautique LINCSystem to automatically increase the stereo volume as the boatspeed incre

4-59Trip ResetThis option resets the trip computer and fuel economycalculations. A DST or GPS device must be installed to receivespeed data in order

4-60You can set individual settings for the available options, or chooseto select RESTORED DEFAULTS for the factory settings. ThePREV and NEXT keys al

4-61Waypoint ManagerWaypoints allow you to mark specific locations by latitude andlongitude. Once the waypoints are established, the WaypointManager a

4-62Track ManagerYou can set up multiple tracks for displaying on the GPS map. TheTrack Manager allows you to select tracks to ‘show’ on the map or‘hi

4-63TroubleshootingGeneral Troubleshooting GuideDisplay appears not to work or doesn’t come “ON”.1. Display could be in sleep mode. Touch a key on the

4-64Section 4Standard EquipmentWatersports Tow PointThe watersports tow-point (pylon) is manufactured from highstrength aluminum alloy, engineered for

4-65Controls and IndicatorsBow Features of Your 216 Nautique The open bow section of your boat has removable cushions. Thecenter section may be equipp

4-66Section 4Driver’s Seat Adjustment The lever under the driver’s seat on the left side allows the seat toslide fore and aft. CORC069A seat or seats

4-67Controls and IndicatorsRearview Mirror Adjustment The rearview mirror can be positioned on the windshield toobserve a skier and traffic behind you

1-4The Safety Alert Symbol means ATTENTION! BECOMEALERT! YOUR SAFETY IS INVOLVED!NOTICEIndicates property damage message.The precautions listed in thi

4-68Section 4Observer’s Seat Lift up on the bottom of the observer’s seat cushion to accessstorage under the bow area. The entire observer’s seat will

4-69Controls and Indicators216 Engine Box Cover Latching/Lifting/RemovalTwo rubber latches (A) hold the top of the engine box to the base.Pull on the

4-70Section 42010 200 Engine Box Cover/Lifting/RemovalThe engine box cover is designed as a two-piece clam shell part. Liftup slightly on the latch lo

4-71Controls and IndicatorsAft Seat Bottom CushionThe aft seat bottom cushion can be removed by releasing the portand starboard rubber latches. The la

4-72Section 4Floor Cooler(s) The floor cooler(s) can be used to store miscellaneous items ordrinks. There is a drain installed in the cooler(s). DO NO

4-73Controls and Indicators216 OnlyThe boarding platform must be attached when the boat is in use.Engine Cooling Water Intake ValveYour boat is equipp

4-74Section 4Battery Disconnect Switch (optional)The battery disconnect switch allows you to isolate all power to theboat. This switch provides positi

4-75Controls and IndicatorsOptional EquipmentStereo and Speaker PodsAll Nautique boats are stereo ready and include an auxiliary input.They have been

4-76Section 4To drain: Press and hold the button until the LED begins to flashand the pump will begin to drain the tank. Press the button againto stop

4-77Controls and IndicatorsBattery Disconnect Switch (if equipped)The battery disconnect switch allows you to isolate all power to theboat. This switc

1-5Boat Safety LabelsYour Nautique boat is affixed with various safety labels at the timeof manufacture. These labels appear at specific locations on

4-78Section 4If your tower is equipped with the optional tower speakers, they canbe adjusted for redirection of sound by loosening the speakermounting

4-79Bimini TopYour Nautique may be equipped with a bimini top which can beused for securing lighter watersports equipment. The top can betilted by rem

4-80COR0238Section 4D-Drive Sec 4_2010:Nautique Ski Sec 4.qxd 7/23/09 4:38 PM Page 80

4-81Controls and IndicatorsOptional Rudder Remote LubeThe service allows for easy access to lubricating the rudder. Theremote lube fitting is located

4-82Section 4NOTESD-Drive Sec 4_2010:Nautique Ski Sec 4.qxd 7/23/09 4:38 PM Page 82

5-1Section 5Boat SystemsKnowing the systems, controls and indicators on your boat isessential for safe and proper operation.When replacement parts are

5-2Fuel System (200 Only)ENGINEFUELTANKFUEL TANKVENTFUELFILLCORC0270Section 5D-Drive Sec 5_2010:Nautique Ski Sec 5.qxd 8/4/09 1:12 PM Page 2

5-3Fuel System (216 Only)ENGINEFUELTANKFUEL TANKVENTFUELFILLFUELFILLCORC096Boat SystemsD-Drive Sec 5_2010:Nautique Ski Sec 5.qxd 7/23/09 4:45 PM Pa

5-4Optional Heater SystemENGINEHEATERCORC098Section 5D-Drive Sec 5_2010:Nautique Ski Sec 5.qxd 7/23/09 4:45 PM Page 4

5-5Boat SystemsBilge SystemNOTICE The Federal Water Pollution Control Act prohibits the discharge ofoil or oily waste into the water. Violators can be

Section 11-6Flame Arrestor Board RacksWalk Through Windshield(216 Only)(200 Only)Dash PodCORC012ACORC204AFIRE EXTINGUISHER SYSTEMArmed when light is o

5-6Bilge System216 200BILGEBILGEDRAINBILGEDRAINCORC100 BILGEBILGEBILGEDRAINBILGEDRAINBILGESection 5D-Drive Sec 5_2010:Nautique Ski Sec 5.qxd 8/4/09

6-1Section 6Getting UnderwayThere are many things to consider to make your boating trip safeand enjoyable. You are responsible for the safety of all p

6-2Safety EquipmentFederal and local laws require certain safety equipment to be on-board at all times. In addition, responsible boaters carry othereq

6-3Gasoline Containing AlcoholThe implementation of ethanol-based fuel is spreading rapidlythroughout the United States. As such, PCM Engines and Naut

6-4Section 6Without proper fuel filtration or fuel stabilization, ethanol blendedfuel may cause the following:• Excessive moisture (water) can cause

6-5Getting UnderwayAfter fueling:1. Tighten the fuel filler cap. Wipe up any spilled fuel.2. Check all fuel lines, hoses and connections for leaks a

6-6Section 6Pre-Operation ChecksIt is the owner’s responsibility to check all of the items listed belowto be certain all preparation steps are complet

6-7Getting UnderwayThe following instructions are very important:• Raise the engine hatch all the way up. Check to see if all theengine drain plugs a

6-8Section 6Checklist before starting boat:1. Engine oil level - boat must be level.2. Transmission oil level - boat must be level.3. Shifting link

6-9Getting Underway• Make sure there are no ropes, gear bags, arms/legs near thebelts and pulleys of the engine. Severe injury can result bybecoming

Boating Safety1-7Fuel Control Cell Flight Control Tower®Side Console (216 Only)Side Console (200 Only)CORC095ACORC011AFailure to follow these guidelin

6-10Section 6In order to prevent personal injury to you or others, the enginecover must be closed whenever the engine is running.• DO NOT operate the

6-11Getting UnderwayIf the engine does not start:• If the fuel filter has been changed or if the fuel system wasrun dry, it will be necessary to cycle

6-12Section 6When the engine starts, move the throttle lever back until theengine is running about 2,500 rpm or less. Check the gauges fornormal readi

6-13Getting UnderwayBreak In ProcedureMake sure all your passengers are properly seated before startingthe break in procedure. After the engine is tho

6-14Section 6NOTICERunning your boat in shallow water can cause propeller shaft,strut, propeller and rudder damage and sand and silt to be pulledinto

6-15Getting UnderwayStoppingStopping the engine immediately after operating at high speed isnot recommended. Allow the engine a two to three minute co

6-16Section 6NOTESD-Drive Sec 6_2010:Nautique Ski Sec 6.qxd 7/23/09 4:46 PM Page 6-16

7-1Section 7RunningNautique urges you and all others operating your boat to seekcertified instruction from the local boating authorities.This section

7-2Maneuvering TechniquesSteering response depends on three factors: rudder position,motion and throttle.Maneuvering in congested areas and advanced c

7-3The effects of unequal propeller thrust, wind and current must alsobe kept in mind. While wind and current may not always bepresent, experienced bo

Section 11-8Boating RegulationsThe U.S. Coast Guard (USCG) is the authority of the waterways;they are there to help the boating public. State boating

7-4Freezing TemperaturesWhen the boat is removed from the water, drain the cooling andheater system (as equipped) completely. AnchoringThere are many

7-5RunningDropping Anchor• Make sure the line is tied to the anchor and tie the otherend to the forward cleat or bow eye.• Head the boat into the wi

7-6Section 7Performance BoatingYour Nautique boat is a high performance boat. DO NOT betempted to push your boat to its limits until you are completel

8-1Section 8Care and MaintenanceThis section describes how to care and maintain your Nautiqueboat. Periodic inspection and maintenance of items listed

8-24. When servicing the ignition switch or any wiring, alwaysdisconnect the battery cables from the battery. 5. Check for water circulation when th

8-3Clean debris from the bowl and screen and rinse parts in freshwater. Insert the screen, place the O-ring in the groove of the bowland screw the bow

8-4Bilge Pumps Check your bilge pumps often to make sure they are operatingefficiently. There are two bilge pumps: one is at the rear of the boatnear

8-5Care and MaintenanceCartridge Replacement1. Turn off power to the bilge pump.2. Unscrew the filter bowl (A) byturning counterclockwise and pourany

8-6Section 8PropellerRemoval1. Remove the cotter pin from the propeller shaft and discard.2. Wedge a piece of 1" x 4" wood between the pro

8-7InstallationBefore placing the propeller on the shaft, look at the keyway on theshaft and in the propeller. Make sure the key slides freely in thes

Boating Safety1-9While operating the boat, the owner/operator is responsible for:• Knowing that all safety equipment and personal flotationdevices (PF

Section 88-8Quick Oil Drain SystemChange the engine oil after the first 25 hours of operation, thenafter every 50 hours. The boat must be removed from

8-9Care and MaintenanceSalt Water Boating NOTICEIf you use your boat in salt water or other unusual waterconditions, fresh water flush your engine and

8-10Section 85. Close the ball valve of step 2 unless the boat is on a trailer orlifted up in the air, in which case it should be left open.6. Run the

8-11Care and Maintenance4. Flush the engine with fresh water after each use. See FreshwaterFlushing Kit - Optional on page 8-9 for more information. 5

8-12Section 8Take care when connecting or disconnecting a battery charger. Besure the charger is turned OFF and unplugged from power sourcewhen you cl

8-13Care and MaintenanceTo clean your battery, remove and wash down the battery case witha diluted ammonia or baking soda/water solution to neutralize

8-14Section 8If your boat’s gelcoat develops a chalky look over a period of timedue to exposure to sun, there are gelcoat buffing and polishingcompoun

8-15Care and MaintenanceCare of Metal• Aluminum care• Stainless care• Chrome• Anodized towersKeep all metal work rinsed and wiped dry. Periodically po

8-16Section 8Common stains and steps to treat:Step #1 Step #2 Step #3Chewing gum D A D then AEye shadow E B E then BEngine oil B B BSpray paint C B BM

8-17Care and MaintenanceTunable RudderThe Tunable Rudder* is designed tooffer easy steering adjustment. Thissystem uses a composite tuning foilwhich i

iiRecord Important InformationIn addition to this manual, your Nautique boat is supplied with componentmanufacturer information such as instructions,

Section 11-10Insurance You must get insurance before operating your new boat. Insurancefor loss by fire, theft or other causes, or liability protectio

8-18Section 8Rudder Remote Lube Fitting (if equipped)The remote lube fitting allows for easy access to lubricating therudder. The remote lube fitting

9-1Section 9TroubleshootingThe following chart will assist you in finding and correcting minorproblems with your Nautique boat. Refer to your engine o

9-2Trouble Check ChartPerformanceSymptom Possible CauseStarter motor will not operate • Shift handle not in NEUTRAL• Battery disconnect switch OFF• Ba

9-3ElectricalSymptom Possible CauseElectrical problem • Open circuit breaker or blownfuse• Loose wiring connection• Defective switch or gaugeDim or no

9-4Section 9NOTESD-Drive Sec 9_2010:Nautique Ski Sec 9.qxd 7/23/09 4:49 PM Page 9-4

10-1Section 10StorageLifting Rings and Lifting EyesYour Nautique has a bow lifting ring and stern lifting eyes. Theseare designed to lift your boat in

10-2NOTICEOnly use a hook that will pass easily through the lifting ringwithout binding. A hook that is too large or off-center could breakthe lifting

10-3Winterizing Your BoatWinter storage procedures vary depending on climate, type ofstorage and length of storage. Check with your dealer/storagefaci

10-4The raw water strainer bowl (A) remains full of water even after therest of the engine cooling water system is drained. To properlywinterize your

Storage10-5Check for Water in Your FuelSystem A small amount of water left in the fuel system for several monthscan result in damage to the fuel syste

Boating Safety1-11• State Boating Offices• Canadian Power and Sail Squadrons• Boat Owners Association of the United States• National Safe Boating Coun

Section 1010-6Add a good quality fuel stabilizer to the fuel prior to winterizing toslow down the rate of fuel decomposition. You can purchase a fuels

10-7Trailer/TraileringHitch If you do not already have a trailer hitch installed on your vehicle,go to a reputable installer to have the proper size h

Section 1010-8Towing Your Boat Read this checklist prior to trailering your boat.• Check wheel lug nuts for tightness.• Be sure the trailer tongue i

10-9Long TripsDO NOT use your boat and trailer to haul excessive gear. Each time you stop on a long trip, check the following:• Make sure the wheel l

10-10NOTESSection 10D-Drive Sec 10_2010:Nautique Ski Sec 10.qxd 7/23/09 4:51 PM Page 10-10

G-1GlossaryABYC – American Boat and Yacht Council, Inc.AFLOAT – On the water.AFT – Toward the rear or stern of the boat.AGROUND – Touching bottom.AMID

G-2CAST-OFF – To unfasten mooring lines in preparation for departure.CATHODE – An electrode carrying a negative charge.CAVITATION – A phenomenon in wh

G-3HYPOTHERMIA – A physical condition where the body loses heatfaster than it can produce it.IN-LINE FUSE – A type of protective fuse located in the p

G-4RUDDER – A vertical metal device used to steer the boatRULES OF THE ROAD – Regulations for preventing collisions onthe water.SACRIFICIAL ANODE – Me

W-1WarrantyNAUTIQUE LIMITEDWARRANTY(Nautique Boats as Originally Manufactured by Correct Craft)The Nautique warranty is backed by a tradition of boat

Section 11-12The capacity plate is used by boat manufacturers participating inthe National Marine Manufacturers Association certificationprogram. Naut

W-2Boat Five (5) Year Transferable Limited Warranty:Nautique warrants to the original user or purchaser, whichevercomes first, that each new Nautique

W-3• Damage or malfunction of a boat, or any componentthereof, resulting from owner use, lack of maintenance,improper maintenance, impact, misuse, neg

W-4Some states do not allow limitations on how long an impliedwarranty lasts. Some states do not allow the exclusion or limitationof incidental or co

W-5NAUTIQUE COASTAL EDITIONLIMITED WARRANTY(Nautique Boats as Originally Manufactured by Correct Craft)The Nautique warranty is backed by a tradition

W-6Boat Three (3) Year Transferable Limited Warranty:Nautique warrants to the original user or purchaser, whichevercomes first, that each new Nautique

W-7• Damage or malfunction of a boat, or any componentthereof, resulting from owner use, lack of maintenance,improper maintenance, impact, misuse, neg

W-8Some states do not allow limitations on how long an impliedwarranty lasts. Some states do not allow the exclusion or limitationof incidental or co

WarrantyW-9D-Drive Warranty_2010:Nautique Ski Warranty.qxd 7/23/09 4:54 PM Page W-9

W-10D-Drive Warranty_2010:Nautique Ski Warranty.qxd 7/23/09 4:54 PM Page W-10

Boating Safety1-13Nautique boat has a required capacity label displaying themaximum weight of people, gear and ballast that can be placed inthe boat.

Section 11-14The operator of the boat is responsible by law to "maintain a properlookout by sight and hearing." The operator must ensure tha

Boating Safety1-15Reporting AccidentsThe USCG requires the owner or operator of a boat involved in anaccident, to report the incident to the proper ma

Section 11-16Equipment requirements for coastal andinland waters differ. Check with localauthorities or the USCG for furtherinformation about coastal

1-17Boating SafetyNOTICE• A Type V PFD must be worn to be counted toward theminimum carriage requirements.• Special PFDs are available for skiing and

1-18Section 1Navigation LightsAll power boats underway between sunset and sunrise must displayproper navigation lights. All boats at anchor must displ

1-19Boating SafetyIf you are required to carry distress signals, you must have threeUSCG approved pyrotechnic devices. Be sure they are inserviceable

iiiBoater’s ChecklistFor improved safety and enjoyment, check each of these items:Check Before You Launch Your Boat:• Read both the engine and the boa

1-20Section 1Recommended SafetyEquipmentAs a precaution, a good boater will avoid potential problems on anouting by having additional equipment on boa

1-21Boating SafetyEmergency Stop Switch andLanyardYour Nautique boat is equipped with an emergency stop switch andlanyard. Nautique strongly recommend

1-22Section 1Replacement lanyards should be of sufficient length to avoidinadvertent activation. Accidental loss of power can be hazardousparticularly

1-23Boating SafetyCapsizing and SwampingA boat may capsize or swamp when least expected. Like fires, try toformulate a plan in advance on what to do i

1-24Section 1Medical EmergencyBe prepared in the event of an emergency. Know how to use yourfirst aid kit. Be aware of any special medical conditions

1-25Boating SafetyNOTICEWeeds can sometimes be removed by shifting to NEUTRAL,pausing for a moment, then shifting to REVERSE to unwind theweeds from t

1-26Section 1Warning Markers Warning MarkersIt is a good idea to ask local authorities if there are hazardous areasand how they are marked. Boaters mu

1-27Boating SafetySwim Area Warning BuoyNavigation markers serve as a means of identifying navigableroutes, and indicate water hazards. Boaters should

1-28Section 1Our EnvironmentAs a boater, you already appreciate nature’s beauty and the peaceof the great outdoors. It is a boater’s responsibility to

1-29Boating SafetyIf the fuel tank is near empty, start fueling the tank very slowly toprevent accidental discharge. Once several gallons have beenadd

ivRestricted AreasBefore boating, check with Local, State and Federal authorities toidentify restricted areas. Because of the threat of terrorism, the

1-30Section 1Cleaning AgentsHousehold cleaners should be used sparingly and not dischargedinto waterways. DO NOT mix cleaners and be sure to use plent

1-31Boating SafetyEvery year tragic deaths occur from the negligence of unsafeboating and dangerous activities. Experts say, "many of these death

1-32Section 1SAFETY ALERT From August 28, 2001:The United States Coast Guard advised boaters not to "Teak/DragSurf." Recent boating fataliti

1-33Boating Safety• DO NOT use the watersports tow point for anything otherthan “towable” watersports.• DO NOT Kitefly.• Make sure that everyone kn

1-34Section 1• Start from a safe place with good forward and peripheralvisibility. • The operator should check direction of the rudder beforestartin

1-35Boating SafetyWhen participating in watersports, be safe and courteous andfollow these guidelines:• Be considerate to fishermen and others you sha

1-36Section 1• Read your owner’s manual and inspect your equipment priorto use.• Ski or ride within your limits.• Always ski or ride in control and at

2-1Section 2Basic Rules of the RoadThe operator is legally required to follow the rules. The followinginformation outlines only the most basic of the

2-2Mooring Buoy – White with Blue BandMay Show White Reflector or LightUSWMS SystemIn the USWMS Lateral System, well-defined channels are markedwith r

2-3Uniform State Regulatory MarkersUSWMS regulatory markers are white with international orangegeometric shapes; you must obey regulatory markers.Unif

vBoating Terminology* An easy way to remember PORT side from STARBOARD side is“PORT” and “LEFT” both have four letters.Product ImprovementBecause of o

2-4FWMS Marking SystemThe middle of the channel is marked with RED and WHITEvertically striped buoys; pass close to these buoys.Spherical Safe Water M

2-5Basic Rules of the RoadLights, bells and horns are used on buoys for night or poor visibilityconditions. Buoys with unique light flashing character

2-6Section 2Crossing SituationIn crossing situations, the boat to the right from the 12 o’clock tothe 4 o’clock position has the right of way. It must

2-7Meeting Head-OnNeither boat has the right of way in this situation. Both boats shoulddecrease speed, turn to the right and pass port-to-port. Howev

Section 22-8OvertakingThe boat that is overtaking one ahead of it is the give-way boat andmust make any adjustments necessary to keep out of the way o

2-9Basic Rules of the RoadThe General Prudential RuleThe General Prudential Rule regarding right of way, is that if acollision appears unavoidable, ne

2-10Section 2NOTESD-Drive Sec 2_2010:Nautique Ski Sec 2.qxd 7/23/09 4:09 PM Page 2-10

3-1Section 3200 and 216Specifications200Length Overall...20' 0" (6.10 m)Length with Pl

3-2216Length Overall...21' 6.5" (6.57 m)Length with Platform...

3-3200 Standard Dash Pod andConsole (without NautiqueLINC)1. Stereo Remote2. Ignition Key3. RPM 3 in 1 Gauge w/Oil & Temp4. Service Soon Light (ca

viWelcome...iRecord Important Information...iiBoater’s Checklist ...iii

3-4 SKI NAUTIQUE 200 OBCORRECT CRAFT, INC.14700 AEROSPACE PKWY.ORLANDO, FL 3283214501450THIS BOAT COMPLIES WITH U.S. COAST GUARD SAFETY STANDARDS IN

3-5200 Team Dash Pod andConsole (with Nautique LINC)1. Pocket Panel2. RCA Video Input3. USB and Auxiliary Input4. Nautique LINC System5. Keypad6. Fire

3-6CORC0266202112V12VCORC08261718161415131211109875432119Section 3D-Drive Sec 3_2010:Nautique Ski Sec 3.qxd 8/4/09 1:03 PM Page 6

3-7200 and 216216 Dash Pod and Console1. Digital Stereo Remote w/Clock2. Tachometer3. Nautique Cruise4. Check Engine Light5. Speedometer6. Service Soo

3-8Section 3START CORC083A1 23456891071112D-Drive Sec 3_2010:Nautique Ski Sec 3.qxd 8/4/09 1:03 PM Page 8

3-9Optional Ignition and SwitchPanel1. Keyless Ignition Key Pad2. Port Ballast – Optional, 216 only3. Starboard Ballast – Optional, 216 only4. Underwa

Section 33-10200 Open Bow Deck LayoutCORC0277213456789101112131415161718192021232224 D-Drive Sec 3_2010:Nautique Ski Sec 3.qxd 8/4/09 1:03 PM

3-11200 and 216200 Open BowDescription1. Bow Navigation Light2. Bow Lifting Ring3. Horn4. Bilge Pump Outlet5. Dash Pod6. Standard Speedometer Calibrat

3-12Section 3200 Closed Bow Deck LayoutCORC0277213456789101112131415161718192021232224 D-Drive Sec 3_2010:Nautique Ski Sec 3.qxd 8/4/09 1:03

3-13200 Closed Bow Description1. Bow Navigation Light2. Bow Lifting Ring3. Horn4. Bilge Pump Outlet5. Dash Pod6. Standard Speedometer Calibration Adju

viiWatersports ResponsibilityCode ...1-35Basic Rules of the Road...2-1Aids to Navigation ...2-1USWMS

3-14Section 3216 Deck Layout12345678931011121314151617188192022212324252726CORC087 D-Drive Sec 3_2010:Nautique Ski Sec 3.qxd 8/4/09 1:03 PM Page 14

3-15216Description1. Bow Navigation Light2. Bow Lifting Ring3. Bilge Pump Outlet4. Dash Pod and Console5. Engine Cover6. Propeller Shaft Stuffing

3-16Section 3Standard and OptionalEquipmentNautique boats are equipped with only the finest standard andoptional equipment available. Your boat’s equi

4-1Section 4Controls and IndicatorsKnowing the systems, controls and indicators on your boat isessential for safe and proper operation.SteeringThe ste

4-2Section 4The helm transfers rotary motion of the steering wheel to linearmotion in the cable which pushes or pulls the rudder. Nautiquerudders are

4-3Controls and IndicatorsCORC143ADOWNCORC142ATUPRI/CKD-Drive Sec 4_2010:Nautique Ski Sec 4.qxd 7/23/09 4:38 PM Page 3

4-4Section 4Shifter/ThrottleYour Nautique boat is equipped with a Shifter/Throttle ControlHandle which features a start-in-gear protection to prevent

4-5Controls and IndicatorsEmergency Stop SwitchThe emergency stop switch will stop the engine when the lanyard ispulled far enough to disengage it fro

4-6Section 4The emergency stop switch can only be effective when it is in goodworking condition.Observe the following:• DO NOT remove or modify an eme

4-7Controls and Indicators• Temp - Indicates the engine coolant temperature. Refer tothe engine manual for normal operating temperature. Afterstarting

viiiFault Code Pop-ups...4-54User Settings...4-56Utilities ...4-58GPS Utilities...

4-8Section 4Control Switches Each electrical circuit on your boat is equipped with a controlswitch. The switches have an indicator light for easy ON/O

4-9Controls and IndicatorsNavigation LightsThe “NAV/ANCHOR” switch controls the navigation lights. Thelaw requires the bow light and the 360 degree li

4-10Section 4The bilge switch must be turned on for this feature to operate. Thiswill not drain significant power from the battery unless the bilgepum

4-11Controls and IndicatorsHeater Switch-Optional The optional heater switch operates the fan to deliver heat to thecockpit. The switch is a four posi

4-12Section 4Fuse PanelThe fuse panel is located on the under side of the deck beneath thedash pod. Fuses protect the circuit by limiting the amount o

4-13Controls and IndicatorsNautique Cruise ControlThe steering wheel hub cruise control remote has five controlbuttons:(ON/OFF)SETCNCL (Cancel)s/RES (

4-14Section 4There are three small lights in the dash display that indicate thestatus of Nautique Cruise. The top light is labeled MPH, the middleone

4-15Controls and IndicatorsButton FunctionThe MPH/RPM button turns Nautique Cruise ON and OFF.• When Nautique Cruise is OFF, a push and release of the

4-16Section 4Dash Pod - Limited or TeamOptional Ignition and Switch PanelNOTICESome of the switches on your boat may not have a function, basedon the

4-17Controls and IndicatorsUnlocked ModeUnlocked mode is entered after the user successfully enters theuser code, presses and releases the start key.

ixStopping ...6-15Docking ...6-15Running...7-1Hydro-Gate™ (200 o

4-18Section 4Automatic Return to Locked ModeIf no keypad activity takes place for 10 hours after unlocking, thesystem will automatically return to the

4-19Controls and IndicatorsNOTICEThe “System Indicator Light” is on the right side of the ignitionkeypad. The “Ignition Indicator Light” is on the lef

4-20Section 4Changing the Primary User CodeNOTICEThe current primary code must be used to change to anotherprimary code.Make sure the system indicator

4-21Controls and IndicatorsTo lock the system, re-enter any of the three codes and press STOP. Erasing the User CodesMake sure the system indicator li

4-22Section 4Refer to Standard Dash Pod in this section for additionalinformation on gauge operation.Speedometer/Depth SounderThe Serial Bus Speedomet

4-23Controls and IndicatorsSpeedometer FunctionThe speedometer measures speed over the water using a paddlewheel sensor. Speedometer CalibrationThe an

4-24Section 4To exit the adjustment procedure without saving, press and hold Mfor two seconds when the display shows “NO SAVE.” Multiple runsin opposi

4-25Controls and IndicatorsWhen there are no alarm conditions, the water depth is displayed.If the signal is weak or lost, or there is no transducer c

4-26Section 4Shallow AlarmThis alarm sounds when the water depth equals or is less than theset value. The display will show “S X.X” which is the cur

4-27Controls and IndicatorsKeel OffsetAdjust depth sounder to measure depth below keel or drive insteadof sensor.The display will show “K X.X” which i