Nautique 216v Manuel d'utilisateur

iDear Nautique Owner,Welcome to the Nautique Family! For over 80 years, Nautique hasbeen dedicated to providing our customers and their families witht

xNAUTIQUE COASTALEDITION LIMITEDWARRANTY ...W-5Lifetime LimitedWarranty...W-5Transferable LifetimeLim

4-24Section 4Gauges (For models not equipped with Nautique LINC)The optional dash pod uses the Faria®Serial BusTMsystem whichreceives information from

4-25Controls and IndicatorsRefer to Standard Dash Pod in this section for additionalinformation on gauge operation.Speedometer/Depth SounderThe Serial

4-26Section 4Speedometer FunctionThe speedometer measures speed over the water using a paddlewheel sensor. Speedometer CalibrationThe analog speedomet

4-27Controls and IndicatorsTo exit the adjustment procedure without saving, press and hold Mfor two seconds when the display shows “NO SAVE.” Multiple

4-28Section 4Canceling Depth AlarmsA depth alarm warning can be temporarily canceled by pressingboth s and t on the speedometer, simultaneously. Aft

4-29Controls and IndicatorsHolding M in for two seconds will save the new shallow setting andchange the display back to the normal depth mode. Set to

4-30Section 4Holding M in for two seconds will save the new keel offset settingand change the display back to the normal depth mode. The keeloffset is

4-31Controls and IndicatorsTachometer/Fuel MonitorThe Tachometer/Fuel Monitor provides both the functions of atachometer and a fuel – engine monitorin

4-32Section 4Engine Hour MeterDisplays the number of hours the engine has been operated. Thedisplay will show “XXXX.XHr.” Engine hours only accumulate

4-33Controls and IndicatorsVoltmeterDisplays the System Voltage. There are no adjustments available. Oil Pressure Displays the current Oil Pressure. T

1-1Section 1Boating SafetySafety While BoatingBoating-related accidents are generally caused by the operator’sfailure to follow basic safety rules or

4-34Section 4Tachometer Display SequenceLCD Alarm Condition DisplaysAlarm messages will be displayed on the Tachometer LCD display.All messages will b

4-35Controls and IndicatorsSevere Conditions – Includes a Flashing Red LightWARNINGS Engine Speed Limiter ActiveKnock Detection System MalfunctionSpar

4-36Section 4Dash Pod Circuit Breaker BoxAll dash pod switches interface with a sealed circuit breaker boxlocated in the driver’s kickboard. The circu

4-37Controls and IndicatorsPower Management Access (PMA) Panel (216V and 226 only)Your Nautique is equipped with a PMA panel to manage othercomponents

4-38Automatic Bilge PanelBilge Pump Only Mode - This feature is activated by a switch locatedon the side console. The switch has three positions, ON,

4-39Nautique LINC SystemProduct InformationThe Nautique LINC System display is designed for instrumentationand control on electronically controlled en

4-40Section 4Basic Navigation FeaturesAll product features are easily accessed through Quick Access Keys,Menus, and Popup Controls. Quick Access Keys

4-41Quick Access Key FeaturesThis section describes the features accessed through the QuickAccess Keys located to the left of the display. These feat

4-42Gauge Display - Soft Key CommandsSection 4VIDEO ON / OFF – displays full-screen input from video in.Pressing the key a second time overlays a redu

4-43Controls and IndicatorsCRUISE SETUP – accesses user profiles and cruise controlsThe Cruise feature is explained in more detail in the “Cruise Setu

1-2• DO NOT operate the boat while under the influence of alcohol or other drugs.• DO NOT stand or allow passengers to stand in the boat, orsit on t

4-44Section 4GPS DisplayThe GPS Display screen can be accessed by pressing the Quick Access Keyor by selecting “GPS Display” from the Menu options. T

4-45GPS Display - Soft Key CommandsControls and IndicatorsUP – LEFT – RIGHT - DOWN – facilitates navigation of the GPSmap by moving the cross-hairs ac

4-46Section 4TRACK INFO – Tracking shows the current route and anywaypoints you have set. A green arrow indicates your currentposition, while the red

4-47Controls and IndicatorsClarion AudioClarion Audio can be accessed by pressing the Quick Access Key orby selecting “Clarion Audio” from the Menu o

4-48Section 4PLAY/PAUSE – toggles between Play and Pause modes when aCD is playing.MUTE – mutes the sound for both FM Band and CD Disc.SOURCE POWER –

Cruise Gauge ScreenThe Cruise Gauge Screen can be accessed by pressing the Quick AccessKey or by selecting “Cruise Gauge Screen” from the Menu options

4-50Section 4CHANGE USER – select a predefined user.Additional Soft Key Commands for Change User include:SELECT – selects the currently displayed user

4-51Controls and IndicatorsVIDEO ON/OFF – toggles the video on or off. Pressing VideoOn/Off from the Cruise Gauge screen launches a small videowindow

4-52Section 4Additional Soft Key Commands for Cruise Setup include:NEW USER – provides an interface to add new user information.Use PREV / NEXT arrows

4-53Controls and IndicatorsAdditional Soft Key Commands for Load USB include:COPY ALL – copies every entry in the currently selected list to theopposi

1-3• Seek shelter from open water if there is threat of lightning.• Operate slowly in congested areas such as marinas andmooring areas.• The bow ma

4-54Section 4MENU OptionsThe MENU is displayed by pressing . The following features areavailable:• Gauge Display – provides a series of screens that

4-55• Cruise Settings – facilitates creation and maintenance ofrider/skier profiles for cruise controls based on userpreference for speed. This featu

4-56Section 4Engine DiagnosticsWhen choosing this selection, the display will query the engine(s)ECU and provide feedback on any diagnostic codes that

4-57Controls and Indicators• FMI – “Failure Mode Indicator” - fault codeThe FMI is defined by SAE J1939. If not translated into text,see the SAE stan

4-58Section 4How to Hide/Show FaultsTo hide the fault code pop-up being displayed on the screen, pressthe soft key next to the “Hide” icon. The pop-up

4-59Controls and IndicatorsUser SettingsUser Settings provide options to specify viewing preferences.Pressing PREV and NEXT navigates through the opti

4-60Section 4NavLightEnabling NavLight allows the unit to automatically display in NightView when the NavLight switch on the console is flipped to ‘On

4-61Controls and IndicatorsAudio IntensityThis function allows the user to program the Nautique LINCSystem to automatically increase the stereo volume

4-62Section 4Trip ResetThis option resets the trip computer and fuel economycalculations. A DST or GPS device must be installed to receivespeed data

4-63Controls and IndicatorsYou can set individual settings for the available options, or chooseto select RESTORED DEFAULTS for the factory settings. T

1-4The Safety Alert Symbol means ATTENTION! BECOMEALERT! YOUR SAFETY IS INVOLVED!NOTICEIndicates a property damage message.The precautions listed in t

4-64Section 4Waypoint ManagerWaypoints allow you to mark specific locations by latitude andlongitude. Once the waypoints are established, the Waypoint

4-65Controls and IndicatorsTrack ManagerYou can set up multiple tracks for displaying on the GPS map. TheTrack Manager allows you to select tracks to

4-66Section 4TroubleshootingGeneral Troubleshooting GuideDisplay appears not to work or doesn’t come “ON”.1. Display could be in sleep mode. Touch a k

4-67Controls and IndicatorsStandard EquipmentWatersports Tow Point (211 only)The watersports tow-point (pylon) is manufactured from highstrength alumi

4-68Section 4Watersports Tow Point (210, 216V, 226 and 230 only)The watersports tow point (pylon) is manufactured from high-strength stainless steel.

4-69Controls and IndicatorsBow Features of Your Nautique The open bow section of your boat has removable cushions. Thecenter section may be equipped w

4-70Section 4Driverʼs Seat AdjustmentThe driver’s seat can be adjusted fore and aft and rotates side-to-side. To slide seat, turn the handle (A) coun

4-71Controls and IndicatorsRearview Mirror AdjustmentThe rearview mirror can be positioned on the windshield toobserve a skier and traffic behind you.

4-72Section 4Observerʼs Seat Lift up on the bottom of the observer’s seat cushion to accessstorage under the bow area. You can leave the seat in the “

4-73Controls and IndicatorsEngine Cover HatchTo open the engine cover hatch, lift the latch and turncounterclockwise. The gas shock will help raise th

1-5Boat Safety LabelsYour Nautique boat is affixed with various safety labels at the timeof manufacture. These labels appear at specific locations on

4-74Section 4Walk-Thru Windshield Opening/Latching There are two latches on the inside starboard side of the walk-thruwindshield. Rotate both of the w

4-75Controls and IndicatorsBoarding PlatformThe boarding platform of your boat is a convenient feature toenhance the watersports experience. There are

4-76Section 4Engine Cooling Water Intake ValveYour Nautique is equipped with a valve (seacock) on the enginecooling water intake. The handle has a sli

4-77Controls and Indicators211216VAT-HANDLECORC0227ACORC0260T-HANDLEV-Drive Sec 4_2010.qxp:Naut Air Sec 4.qxd 7/22/09 1:45 PM Page 77

4-78Section 4226230ACORC0258T-HANDLET-HANDLECORC0246AV-Drive Sec 4_2010.qxp:Naut Air Sec 4.qxd 7/22/09 1:45 PM Page 78

4-79Controls and IndicatorsFuel TankThere is a fuel tank fill cap on the port and starboard side for addedconvenience. Use the fuel tank fill cap key

4-80Section 4Battery Selector SwitchThe battery selector switch allows you to isolate the boat from thebatteries, and switch from one battery to the o

4-81Controls and IndicatorsFolding Instructions for Flight Control Tower®– OptionalFlight Control Tower®Series 4 (FCT 4) Folding InstructionsThe Fligh

4-82Section 4210, 216V, 226 and 230 - Flight Control Tower®Series 3(FCT 3)Remove all boards from the board racks prior to folding the tower.Make sure

4-83Controls and IndicatorsIf your tower is equipped with the optional tower speakers, they canbe adjusted for redirection of sound by loosening the s

Section 11-6Flame Arrestor Board RacksWalk Through Windshield211210, 216V, 226 and 230Dash PodCORC204FIRE EXTINGUISHER SYSTEMArmed when light is on.Se

4-84Section 4Bimini TopYour Nautique may be equipped with a bimini top which can beused for securing lighter watersports equipment. The top can betilt

4-85Controls and IndicatorsCOR0238V-Drive Sec 4_2010.qxp:Naut Air Sec 4.qxd 7/22/09 1:45 PM Page 85

4-86Section 4Ballast TanksThe tanks increase the wake for wake boarding, making yourNautique the most versatile watersports tow package in the world.

4-87Controls and IndicatorsBallast Control Gauges - 211Ballast Control Gauges - 210, 216V, 226 and 230CORC208AWATEREF1/2WATEREF1/2WATEREF1/2CORC140AV-

4-88Optional AccessoriesStereo and Speaker PodsAll Nautique boats are stereo ready and include an auxiliary input.They have been pre-wired for your Na

4-89• Sun Pad Cargo Net - 210 Only• Sun Pad Cargo Net - 211 OnlyCORC217CORC179Controls and IndicatorsV-Drive Sec 4_2010.qxp:Naut Air Sec 4.qxd 7/22

4-90NOTESSection 4V-Drive Sec 4_2010.qxp:Naut Air Sec 4.qxd 7/22/09 1:45 PM Page 90

5-1Section 5Boat SystemsKnowing the systems, controls and indicators on your boat isessential for safe and proper operation.When replacement parts are

5-2CORC0243FUEL TANK VENTFUEL FEEDFUEL RETURNFUEL FILLFUEL FILLFUEL FILTERSection 5V-Drive Sec 5_2010.qxp:Naut Air Sec 5.qxd 7/22/09 1:49 PM Page 5

5-3Ballast Tanks and BilgeSystemNOTICE The Federal Water Pollution Control Act prohibits the discharge ofoil or oily waste into the water. Violators c

Boating Safety1-7Fuel Control Cell Flight Control Tower®211 210, 216V, 226 and 230Side ConsoleCORC00314700 Aerospace Pky. Orlando, FL 32809Never run e

5-4Ballast Tank Valves - 210Ballast Tank Valves - 211T-HANDLESTARBOARD TANK INTAKE/DRAIN VALVEBELLY TANKINTAKE/DRAIN VALVEENGINE COOLINGVALVEPORT TANK

5-5Boat SystemsBallast Tank Valves - 216VBallast Tank Valves - 226T-HANDLESTARBOARD TANK INTAKE/DRAIN VALVEBELLY TANKINTAKE/DRAINVALVEPORT TANKINTAKE/

5-6Ballast Tank Valves - 230T-HANDLESTARBOARD TANK INTAKE/DRAIN VALVEBELLY TANKINTAKE/DRAIN VALVEENGINE COOLINGVALVEPORT TANKINTAKE/DRAINVALVECORC0256

5-7Boat SystemsBelly Ballast Tank and Bilge SystemCORC0229BILGE DRAINHULL VENTHULL VENTAFT BILGE PUMPBELLY TANKINTAKE/DRAINVALVEBELLY TANKPUMPBELLY BA

5-8Section 5Port and Starboard Ballast TanksCORC0230REAR BALLAST TANKPORT TANK PUMPSTARBOARD TANK PUMPSTARBOARD INTAKE/DRAINVALVEPORTINTAKE/DRAINVALVE

5-9Boat Systems12-Volt SystemBATTERYNEGATIVE STUDON MOTORCORC0233POWER MANAGEMENT ACCESS/CIRCUIT BREAKERS/BATTERY SWITCH/BREAKER PANELV-Drive Sec 5_20

5-10Section 5Heater System-OptionalENGINE CORC0231HEATERHEATERINTAKE GRILLEHEATERDUCTSV-Drive Sec 5_2010.qxp:Naut Air Sec 5.qxd 7/22/09 1:49 PM Pag

5-11Boat SystemsThe heater system has a heating core, ducts, diffusers and a three-speed fan to deliver heat to the cockpit and windshield. The ductdi

NOTESSection 55-12V-Drive Sec 5_2010.qxp:Naut Air Sec 5.qxd 7/22/09 1:49 PM Page 5-12

6-1Section 6Getting UnderwayThere are many things to consider to make your boating trip safeand enjoyable. You are responsible for the safety of all p

Section 11-8Boating RegulationsThe U.S. Coast Guard (USCG) is the authority of the waterways;they are there to help the boating public. State boating

6-2Safety EquipmentFederal and local laws require certain safety equipment to be on-board at all times. In addition, responsible boaters carry othereq

6-3Gasoline Containing AlcoholThe implementation of ethanol-based fuel is spreading rapidlythroughout the United States. As such, PCM Engines and Naut

6-4Without proper fuel filtration or fuel stabilization, ethanol blendedfuel may cause the following:• Excessive moisture (water) can cause lean oper

6-5Getting UnderwayBoardingWhen boarding the boat, always step in. DO NOT jump. Avoidstepping on fiberglass or other potentially slippery surfaces. Bo

6-6Section 6Pre-Operation ChecksIt is the owner’s responsibility to check all of the items listed belowto be certain all preparation steps are complet

6-7The following instructions are very important:• Raise the engine hatch all the way up. Check to see if all theengine drain plugs are in place. Mak

Section 66-8Checklist before starting boat:1. Engine oil level - boat must be level.2. Transmission oil level - boat must be level.3. Shifting link

6-9Getting Underway• Make sure there are no ropes, gear bags, arms/legs near thebelts and pulleys of the engine. Severe injury can result bybecoming

6-10Section 6In order to prevent personal injury to you or others, the enginecover must be closed whenever the engine is running.• DO NOT operate the

6-11Getting UnderwayIf the engine does not start:• If the fuel filter has been changed or if the fuel system wasrun dry, it will be necessary to cycle

Boating Safety1-9• Knowing that all safety equipment and personal flotationdevices (PFDs) are in good condition and suitable for yourboat and passenge

6-12Section 6When the engine starts, move the throttle lever back until theengine is running about 2,500 rpm or less. Check the gauges fornormal readi

6-13Getting UnderwayBreak In ProcedureMake sure all your passengers are properly seated before startingthe break in procedure. After the engine is tho

6-14Section 6NOTICERunning your boat in shallow water can cause propeller shaft,strut, propeller and rudder damage and sand and silt to be pulledinto

6-15Getting UnderwayStoppingStopping the engine immediately after operating at high speed isnot recommended. Allow the engine a two to three minute co

6-16Section 6NOTESV-Drive Sec 6_2010.qxp:Naut Air Sec 6.qxd 7/22/09 1:46 PM Page 6-16

7-1Section 7RunningNautique urges you and all others operating your boat to seekcertified instruction from the local boating authorities.This section

7-2Maneuvering TechniquesSteering response depends on three factors: rudder position,motion and throttle.Maneuvering in congested areas and advanced c

7-3The effects of unequal propeller thrust, wind and current must alsobe kept in mind. While wind and current may not always bepresent, experienced bo

7-4Freezing TemperaturesWhen the boat is removed from the water, drain the cooling andheater system (as equipped) completely. AnchoringThere are many

7-5RunningDanforth AnchorDropping Anchor• Make sure the line is tied to the anchor and tie the otherend to the forward cleat or bow eye.• Head the b

iiRecord Important InformationIn addition to this manual, your Nautique boat is supplied with componentmanufacturer information such as instructions,

Section 11-10Insurance You must get insurance before operating your new boat. Insurancefor loss by fire, theft or other causes, or liability protectio

7-6Section 7Anchoring• Pull on the line to make sure the anchor is holding.• Occasionally check your position against the shoreline. If theanchor is

7-7RunningPerformance BoatingYour Nautique boat is a high performance boat. DO NOT betempted to push your boat to its limits until you are completelyf

7-8Section 7NOTESV-Drive Sec 7_2010.qxp:Naut Air Sec 7.qxd 7/22/09 1:49 PM Page 7-8

8-1Section 8Care and MaintenanceThis section describes how to care and maintain your Nautiqueboat. Periodic inspection and maintenance of items listed

8-24. When servicing the ignition switch or any wiring, alwaysdisconnect the battery cables from the battery. 5. Check for water circulation when th

8-3Some engines are equipped with a closed cooling system with a self-contained reservoir for engine coolant. Self-contained systems areequipped with

8-4Cartridge Replacement1. Turn off power to the bilge pump.2. Unscrew the filter bowl (A) by turning counterclockwise andpour any excess bilge water

8-5Care and MaintenancePropellerRemoval1. Remove the cotter pin from the propeller shaft and discard.2. Wedge a piece of 1" x 4" wood betw

8-6Section 8Use a propeller puller to remove the propeller, then remove thekey from the keyway. Inspect the keyways and key for any damage.Installatio

8-7Propeller Shaft Stuffing Box The stuffing box is designed to prevent water from coming throughthe through-hull fittings. These are found on the pro

Boating Safety1-11• American Red Cross• U.S. Coast Guard Auxiliary• U.S. Power Squadrons• State Boating Offices• Canadian Power and Sail Squadrons• Bo

Section 88-8Salt Water Boating NOTICEIf you use your boat in salt water or other unusual waterconditions, fresh water flush your engine and cooling sy

8-9Care and Maintenance5. Close the ball valve of step 2 unless the boat is on a trailer orlifted up in the air, in which case it should be left open.

8-10Section 8DO NOT make or break electrical circuits at the battery terminals;a spark will occur when a live circuit is opened or made. Turn off allc

8-11Care and MaintenanceGelcoat Maintenance Your Skipper’s Kit included samples of quality boat care productsrecommended by Nautique. Nautique is prou

8-12Section 8Sudden changes in temperature can affect gelcoat. If you moveyour boat from outdoors to a heated area, allow the temperaturechange to be

8-13Care and MaintenanceCommon stains and steps to treat:Step #1 Step #2 Step #3Chewing gum D A D then AEye shadow E B E then BEngine oil B B BSpray p

8-14Section 8Tunable RudderThe Tunable Rudder* is designed tooffer easy steering adjustment. Thissystem uses a composite tuning foilwhich is located a

8-15Care and MaintenanceRudder Remote Lube FittingThe remote lube fitting allows for easy access to lubricating therudder. The remote lube fitting is

8-16Section 8TransmissionAllow the transmission to cool and check with the boat level.1. Remove the drain/fill plug from the transmission.2. Verify th

8-17Shift CableLubricate pivot points and exposed cable with SAE 30W-30 engineoil.Care and MaintenanceLUBRICATIONPOINTSCORC211V-Drive Sec 8_2010.qxp:N

Section 11-12The capacity plate is used by boat manufacturers participating inthe National Marine Manufacturers Association certificationprogram. Naut

8-18NOTESSection 8V-Drive Sec 8_2010.qxp:Naut Air Sec 8.qxd 7/22/09 1:47 PM Page 8-18

9-1Section 9TroubleshootingThe following chart will assist you in finding and correcting minorproblems with your Nautique boat. Refer to your engine o

9-2Trouble Check ChartPerformanceSymptom Possible CauseStarter motor will not operate • Shift handle not in NEUTRAL• Battery Selector switch OFF• Batt

9-3ElectricalSymptom Possible CauseElectrical problem • Open circuit breaker or blownfuse• Loose wiring connection• Defective switch or gaugeDim or no

9-4Section 9NOTESV-Drive Sec 9_2010.qxp:Naut Air Sec 9.qxd 7/22/09 1:53 PM Page 9-4

10-1Section 10StorageLifting Rings and Lifting EyesThe 211 has lifting rings at the bow and at the stern. The 210, 216V,226 and 230 have a bow liftin

10-2NOTICEOnly use a hook that will pass easily through the lifting rings oreyes without binding. A hook that is too large or off-center couldbreak th

10-3Winterizing Your BoatWinter storage procedures vary depending on climate, type ofstorage and length of storage. Check with your dealer/storagefaci

10-4The raw water strainer bowl (A) remains full of water even after therest of the engine cooling water system is drained. To properlywinterize your

Storage10-5Check For Water in Your FuelSystem A small amount of water left in the fuel system for several monthscan result in damage to the fuel syste

Boating Safety1-13maximum weight of people, gear and ballast that can be placed inthe boat. Always be aware of the load in your boat and do not loadth

Section 1010-6Add a good quality fuel stabilizer to the fuel prior to winterizing toslow down the rate of fuel decomposition. You can purchase a fuels

10-7Trailer/TraileringHitch If you do not already have a trailer hitch installed on your vehicle,go to a reputable hitch company to have the proper si

Section 1010-8Towing Your Boat Read this checklist prior to trailering your boat.• Check wheel lug nuts for tightness.• Be sure the trailer tongue i

10-9Storage• Examine the hitch connection to be sure it is firmly attachedand the safety pin and chains are securely fastened.• Make sure all traile

10-10Section 10NOTESV-Drive Sec 10_2010.qxp:Naut Air Sec 10.qxd 7/22/09 1:50 PM Page 10-10

G-1GlossaryABYC – American Boat and Yacht Council, Inc.AFLOAT – On the water.AFT – Toward the rear or stern of the boat.AGROUND – Touching bottom.AMID

G-2CAST-OFF – To unfasten mooring lines in preparation for departure.CATHODE – An electrode carrying a negative charge.CAVITATION – A phenomenon in wh

G-3HYPOTHERMIA – A physical condition where the body loses heatfaster than it can produce it.IN-LINE FUSE – A type of protective fuse located in the p

G-4RUDDER – A vertical metal device used to steer the boatRULES OF THE ROAD – Regulations for preventing collisions onthe water.SACRIFICIAL ANODE – Me

W-1WarrantyNAUTIQUE LIMITEDWARRANTY(Nautique Boats as Originally Manufactured by Correct Craft)The Nautique warranty is backed by a tradition of boat

Section 11-14The operator of the boat is responsible by law to “maintain a properlookout by sight and hearing.” The operator must ensure thathe/she ha

W-2Boat Five (5) Year Transferable Limited Warranty:Nautique warrants to the original user or purchaser, whichevercomes first, that each new Nautique

W-3• Damage or malfunction of a boat, or any componentthereof, resulting from owner use, lack of maintenance,improper maintenance, impact, misuse, neg

W-4Some states do not allow limitations on how long an impliedwarranty lasts. Some states do not allow the exclusion or limitationof incidental or co

WarrantyW-5NAUTIQUE COASTAL EDITIONLIMITED WARRANTY(Nautique Boats as Originally Manufactured by Correct Craft)The Nautique warranty is backed by a tr

W-6Boat Three (3) Year Transferable Limited Warranty:Nautique warrants to the original user or purchaser, whichevercomes first, that each new Nautique

W-7• Damage or malfunction of a boat, or any componentthereof, resulting from owner use, lack of maintenance,improper maintenance, impact, misuse, neg

W-8Some states do not allow limitations on how long an impliedwarranty lasts. Some states do not allow the exclusion or limitationof incidental or co

W-9WarrantyV-Drive Warr_2010.qxp:Naut Air Warr.qxd 7/22/09 1:52 PM Page W-9

W-10V-Drive Warr_2010.qxp:Naut Air Warr.qxd 7/22/09 1:52 PM Page W-10

Boating Safety1-15Reporting AccidentsThe USCG requires the owner or operator of a boat involved in anaccident, to report the incident to the proper ma

Section 11-16Equipment requirements for coastal andinland waters differ. Check with localauthorities or the USCG for furtherinformation about coastal

1-17Boating SafetyNOTICE• A Type V PFD must be worn to be counted toward theminimum carriage requirements.• Special PFDs are available for skiing and

1-18Section 1Navigation LightsAll power boats underway between sunset and sunrise must displayproper navigation lights. All boats at anchor must displ

1-19Boating SafetyIf you are required to carry distress signals, you must have threeUSCG approved pyrotechnic devices. Be sure they are inserviceable

iiiBoater’s ChecklistFor improved safety and enjoyment, check each of these items:Check Before You Launch Your Boat:• Read both the engine and the boa

1-20Section 1Recommended SafetyEquipmentAs a precaution, a good boater will avoid potential problems on anouting by having additional equipment on boa

1-21Boating SafetyEmergency Stop Switch andLanyardYour Nautique boat is equipped with an emergency stop switch andlanyard. Nautique strongly recommend

1-22Section 1Replacement lanyards should be of sufficient length to avoidinadvertent activation. Accidental loss of power can be hazardousparticularly

1-23Boating SafetyCapsizing and SwampingA boat may capsize or swamp when least expected. Like fires, try toformulate a plan in advance on what to do i

1-24Section 1Medical EmergencyBe prepared in the event of an emergency. Know how to use yourfirst aid kit. Be aware of any special medical conditions

1-25Boating SafetyNOTICEWeeds can sometimes be removed by shifting to NEUTRAL,pausing for a moment, then shifting to REVERSE to unwind theweeds from t

1-26Section 1Warning Markers Warning MarkersIt is a good idea to ask local authorities if there are hazardous areasand how they are marked. Boaters mu

1-27Boating SafetySwim Area Warning BuoyNavigation markers serve as a means of identifying navigableroutes, and indicate water hazards. Boaters should

1-28Section 1Our EnvironmentAs a boater, you already appreciate nature’s beauty and the peaceof the great outdoors. It is a boater’s responsibility to

1-29Boating SafetyIf the fuel tank is near empty, start fueling the tank very slowly toprevent accidental discharge. Once several gallons have beenadd

ivRestricted AreasBefore boating, check with Local, State and Federal authorities toidentify restricted areas. Because of the threat of terrorism, the

1-30Section 1Cleaning AgentsHousehold cleaners should be used sparingly and not dischargedinto waterways. DO NOT mix cleaners and be sure to use plent

1-31Boating SafetyEvery year tragic deaths occur from the negligence of unsafeboating and dangerous activities. Experts say, "many of these death

1-32Section 1SAFETY ALERT From August 28, 2001:The United States Coast Guard advised boaters not to "Teak/DragSurf." Recent boating fataliti

1-33Boating Safety• DO NOT Kitefly.• Make sure that everyone knows and uses approved skiinghand signals and common skiing courtesy.• Be sure to tur

1-34Section 1• The operator should be primarily aware of what is occurringin front of the boat, but be aware of skier’s progress. • Be sure to inspe

1-35Boating SafetyWhen participating in watersports, be safe and courteous andfollow these guidelines:• Be considerate to fishermen and others you sha

1-36Section 1• Read your owner’s manual and inspect your equipment priorto use.• Ski or ride within your limits.• Always ski or ride in control and at

2-1Section 2Basic Rules of the RoadThe operator is legally required to follow the rules. The followinginformation outlines only the most basic of the

2-2Mooring Buoy – White with Blue BandMay Show White Reflector or LightUSWMS SystemIn the USWMS Lateral System, well-defined channels are markedwith r

2-3Uniform State Regulatory MarkersUSWMS regulatory markers are white with international orangegeometric shapes; you must obey regulatory markers.Unif

vBoating Terminology* An easy way to remember PORT side from STARBOARD side is“PORT” and “LEFT” both have four letters.Product ImprovementBecause of o

2-4FWMS Marking SystemThe middle of the channel is marked with RED and WHITEvertically striped buoys; pass close to these buoys.Spherical Safe Water M

2-5Basic Rules of the RoadLights, bells and horns are used on buoys for night or poor visibilityconditions. Buoys with unique light flashing character

2-6Section 2Crossing SituationIn crossing situations, the boat to the right from the 12 o’clock tothe 4 o’clock position has the right of way. It must

2-7Meeting Head-OnNeither boat has the right of way in this situation. Both boats shoulddecrease speed, turn to the right and pass port-to-port. Howev

Section 22-8OvertakingThe boat that is overtaking one ahead of it is the give-way boat andmust make any adjustments necessary to keep out of the way o

2-9Basic Rules of the RoadThe General Prudential RuleThe General Prudential Rule regarding right of way, is that if acollision appears unavoidable, ne

2-10Section 2NOTESV-Drive Sec 2_2010.qxp:Naut Air Sec 2.qxd 7/22/09 1:48 PM Page 2-10

3-1Section 3210, 211, 216V, 226 and 230Specifications210Length Overall...21' 0" (6.40

3-2216VLength Overall...20' 11" (6.38 m)Length with Platform...

3-3210, 211, 216V, 226 and 230 230Length Overall...23' 1.5" (7.05 m)Length with Platform.

viWelcome...iRecord Important Information...iiBoater’s Checklist ...iii

210 SE Dash Pod and ConsoleCORC0263BILGENAV/ANCHORBLOWERHORNBILGENAV/ANCHORBLOWERHORN1112131412345678910151617181920212223243-4Section 31. Digital Ste

3-5210, 211, 216V, 226 and 230 211 SE Dash Pod and Console12V 12V CORC0247WATER E F 1/2 WATER E F 1/2 WATER E F 1/2 2122201819161510987543 2 123176

3-6210, 216V, 226, 230 LimitedDash Pod and Console withoutNautique LINC SystemCORC024912345678910111213141516171819202122Section 31. Digital Stereo Re

3-7210, 216V, 226, 230 DashPod and Console withNautique LINC SystemCORC02501712345678910111213141516210, 211, 216V, 226 and 230 1. Pocket Panel2. War

3-8Section 3Ignition and Switch Panel1. Keyless Ignition Key Pad2. Belly Ballast (if equipped)3. Port Ballast (if equipped)4. Starboard Ballast (i

3-9Keys1. Fuel Tank Fill Cap Key2. Hatch Latch KeyCORC02712CORC027B12210, 211, 216V, 226 and 230 V-Drive Sec 3_2010.qxp:Naut Air Sec 3.qxd 7/22/09 1

3-10Section 3210 Deck LayoutCORC21412345678910113121314151617181920312110222523242628272930V-Drive Sec 3_2010.qxp:Naut Air Sec 3.qxd 7/22/09 1:51 PM

3-11210, 211, 216V, 226 and 230 210Description1. Bow Navigation Light2. 12V Port3. Bilge Pump Outlet4. Belly Tank Vent5. Dash Pod & Console6. Spor

3-12Section 3211 Deck LayoutCORC088 21CORC141 345678910111213151618202111232222262724252829224141719V-Drive Sec 3_2010.qxp:Naut Air Sec 3.qxd 7/22/09

3-13210, 211, 216V, 226 and 230 211Description1. Bow Navigation Light2. Bow Lifting Ring3. 12V Port4. Bilge Pump Outlet5. Belly Tank Vent6. Dash

viiWatersports ResponsibilityCode ...1-35Basic Rules of the Road ...2-1Aids to Navigation ...2-1USWMS

3-14Section 3216V Deck Layout21CORC023934456810111197121415222526232427373635343332313029281313161718192021V-Drive Sec 3_2010.qxp:Naut Air Sec 3.qxd

3-15210, 211, 216V, 226 and 230 216VDescription1. Bow Navigation Light2. Bow Lifting Ring3. Anchor Storage4. Storage5. Cruise Control GPS Module6. Bel

3-16Section 3226 Deck Layout2423251335678999101012121113141415161718192021222426272829303132333435363738CORC0245V-Drive Sec 3_2010.qxp:Naut Air Sec 3.

3-17210, 211, 216V, 226 and 230 226Description1. Bow Navigation Light2. Bow Lifting Ring3. Storage4. Cruise Control GPS Module5. Belly Tank Vent6. Bat

3-18Section 3230 Deck Layout312345678910114121314151617181920151521182212232425263CORC213V-Drive Sec 3_2010.qxp:Naut Air Sec 3.qxd 7/22/09 1:51 PM

3-19210, 211, 216V, 226 and 230 230Description1. Bow Navigation Light2. Bow Lifting Ring3. 12V Port4. Bilge Pump Outlet5. Belly Ballast Tank Vent6

Standard and OptionalEquipmentNautique boats are equipped with only the finest standard andoptional equipment available. Your boat’s equipment will va

4-1Section 4Controls and IndicatorsKnowing the systems, controls and indicators on your boat isessential for safe and proper operation.SteeringThe ste

4-2Section 4The helm transfers rotary motion of the steering wheel to linearmotion in the cable which pushes or pulls the rudder. Nautiquerudders are

4-3Controls and IndicatorsCORC143CORC142B SLALOMV-Drive Sec 4_2010.qxp:Naut Air Sec 4.qxd 7/22/09 1:44 PM Page 3

viiiProduct Information ...4-39Care and Maintenance ...4-39Basic Navigation Features ...4-40Quick Access Keys ...4-40Quick Access Ke

4-4Section 4Shifter/ThrottleYour Nautique boat is equipped with a Shifter/Throttle ControlHandle which features a start-in-gear protection to prevent

4-5Controls and IndicatorsEmergency Stop SwitchThe emergency stop switch will stop the engine when the lanyard ispulled far enough to disengage it fro

4-6Section 4The emergency stop switch can only be effective when it is in goodworking condition.Observe the following:• DO NOT remove or modify an eme

4-7Controls and Indicators• Oil Pressure - Measures the pressure of the engine’slubricating oil. Refer to the engine manual for normaloperating pressu

4-8Section 4Speedometer CalibrationThe speedometer calibration control knob is located on the underside of the deck beneath the dash pod above the dri

4-9Controls and IndicatorsNavigation LightsThe “NAV/ANCHOR” switch controls the navigation lights. Thelaw requires the bow light and the 360 degree li

4-10Section 4The bilge switch must be turned on for this feature to operate. Thiswill not drain significant power from the battery unless the bilgepum

4-11Controls and IndicatorsIgnition KeyswitchThis keyswitch starts and stops the engine. A built-in protectionsystem prevents the engine from starting

4-12Section 4• Oil Pressure - Measures the pressure of the engine’slubricating oil. Refer to the engine manual for normaloperating pressure. Many seri

4-13Controls and IndicatorsUnderwater LightsThis switch controls the transom underwater lights. DO NOToperate lights while the boat is out of the wate

ixSteering...6-14Stopping ...6-15Docking ...6-15Running...

4-14Section 4Engine Compartment/Bilge Area BlowerThe blower switch activates the engine compartment ventilationblower to remove explosive fumes from t

4-15Controls and IndicatorsBilge PumpThe bilge switch turns on the bilge pump to remove excess waterfrom the bottom of the boat. The pump turns on or

4-16Section 412-Volt Port This receptacle can be used to power and charge cellular phones,MP3 players, video cameras or other electronics. These recep

4-17Controls and IndicatorsLocked ModeWhen the boat’s battery is first connected, the unit is in lockedmode. In this mode, only the horn, bilge pump,

4-18Section 4Automatic Return to Locked ModeIf no keypad activity takes place for 10 hours after unlocking, thesystem will automatically return to the

4-19Controls and IndicatorsNOTICEThe “System Indicator Light” is on the right side of the ignitionkeypad. The “Ignition Indicator Light” is on the lef

4-20Section 4Changing the Primary User CodeNOTICEThe current primary code must be used to change to anotherprimary code.Make sure the system indicator

4-21Controls and IndicatorsErasing the User CodesMake sure the system indicator light is OFF. Enter the Master Embedded Code, press and release the 1/

4-22Section 4There are three small lights in the dash display that indicate thestatus of Nautique Cruise. The top light is labeled MPH, the middleone

4-23Controls and IndicatorsButton FunctionThe MPH/RPM button turns Nautique Cruise ON and OFF.• When Nautique Cruise is OFF, a push and release of the